CaliforniaSpecial.com -- Message Boards -- 1968 California Special Limited Edition Ford Mustang GT/CS
D I S C U S S I O N . F O R U M
COMMUNITY
1968 GT/CS & HCS
2007+ GT/CS
1966-1967 HCS

Vote!

Old 06/08/2003, 09:52 PM   #1
Guest
 

Posts: n/a

Fired up the CS today--at long last! (long)

I certainly can't be accused of being in a hurry! I bought a donor engine back in February or March and just today started it for the very first time.

As some of you may know, this car has been off the road since 1979. It is a 302/4V car, and I found a killer deal on a 302 out of a wrecked car and decided to install it while considering the rebuild on the original (read: I'm Mustang poor right now!).

The engine also came with a C-4 that we installed as a unit, but I didn't realize the tailhousing portion was damaged in the accident until I had changed the filter and drainpan gasket and was filling the thing; quart #4 started leaking all over the floor from a crack up beneath the transmission mount (which was broken on the donor car--should've had a clue, but it looked fine when I cleaned the thing up). My '68 tranny is being rebuilt and beefed up right now--hope to have it back to reinstall in a couple of weeks.

I haven't reinstalled the original 4 barrel intake and carburetor yet (sent the carb out to Pony Carbs for a rebuild--looks great, anyway!), but I had to swap the harmonic balancer and pulley set to run the power steering pump. I also used the original alternator, exhaust manifolds, speedometer gear, and little wiring attachment for the back-up lights. I took the radiator to a local shop and had it checked out before reinstalling. I replaced the water pump (because the fan pulley was broken and I was worried it might've been damaged in the accident) and used new motor mounts and transmission mount.

I hooked up the stock exhaust system, which is in very good shape for being 23+ years old, and ran the gas line from a can and the engine fired right up! You would not believe the cloud of orange rust/smoke that blew out of the tailpipe!!! We were driven from the garage until it cleared. Then all the penetrating oil that had been sprayed on the exhaust manifolds (so I could remove them from the old engine) started smoking off, but that wasn't as bad.

I'm thinking I'll blow air thru the gaslines into the tank, which had been removed, so it sat drained all these years but looks very dusty inside. Then I'll try and vacuum out the tank somehow to clean it. Then maybe dump a little gas in and drain it back out to remove the remaining debris?

When hooking up the negative battery cable, there was a MAJOR spark, so one of the next little (unanticipated) steps in this long progression is looking for a electrical drain; I think this'll be easier to do w/o the fenders and such, so I need roll on that now while the car is partially disassembled. I also have all four wheels off in anticipation of redoing the brake system; I have a new mastercylinder waiting as well.

Once the mechanical details get ironed out, then real fun will begin: reassembling the front end and fenders, all removable parts from the rear of the car (bumpers. lights, etc), the entire interior, the heater assembly, and probably a bunch of other little things I can't think of or don't know about right now--the worst part is that I have only done about 1/4 of the disassembly myself, I bought it torn apart with many little bags of screws and such with labels of where they came from. I just hope there aren't too many pieces missing :-\

I just wanted to share this today because I am fairly impressed with myself--since I am a girl (kind of an old girl now, tho) who only changed the oil in my car for the first time in my life 2 1/2 years ago... My "other half" helps a lot, but he's really crabbby when I ask and we end up fighting when we work on my car, so I try to do as much myself as I can--keeping the peace in the family and all, you know!
  Reply With Quote
Old 06/09/2003, 08:11 AM   #2
Calspecialdreamer
 

Joined: Feb 03
Posts: 207

Re:Fired up the CS today--at long last! (long)

Deadstang,
I am extremely impressed! Can't believe you have tackled this after just learning to change the oil! Good luck and keep us posted.....

Calspecialdreamer is offline   Reply With Quote
Old 06/09/2003, 07:22 PM   #3
rjw
 
rjw's Avatar
 

Joined: Aug 02
Posts: 257

Re:Fired up the CS today--at long last! (long)

Now if you could only talk to my wife...Congrats on getting so much done; it is very satisfying to see progress in the making!
Richard
rjw is offline   Reply With Quote
Old 06/09/2003, 09:03 PM   #4
cmacias24
 

Location: Los Angeles, CA
Joined: Sep 02
Posts: 90

Send a message via MSN to cmacias24
My Garage
Re:Fired up the CS today--at long last! (long)

Not bad.... I remember those days last year. I purchased my car from here 1 1/2 years ago and boy was I in for something. The discription of the car was not exactly what it seemed to be. It was 1968 gt/cs originally light blue 33k original miles. ready for paint. please call.
I called the guy in origon and said that the car ran good and was involved in a front end wreak but it was sitting at a body shop when all the sheet metal was taken care of. He said that he went through and promered the car and took off the winshields. So I jumped on it. Total price......5500 with shipping.
I thought I had a steal. 1968 Cal Special? Man, my dream car. I had a 1967 coupe that I was currently restoring and was done except for the paint. I sold it and got my dream car. Go to page 5 in the gallery. The car I got was taken apart, no screws and everything needs to be rebuilt including the interior. I even got winstion to send me pics of the screws to put the body back together.
Well enough of that, I got the car painted and I'm driving it to work. The interior is shot, but lucky me the engine is working perfectly. I picked up a tranny off a friend who is going from mild to wild on his 67, so for now I'm in good shape. yeah.... 10k later hahaha
Thanks to the people here I have never been alone. Don't worry about your other half, we are your other half.
cmacias24 is offline   Reply With Quote
Old 06/10/2003, 06:48 AM   #5
StraightSix
 

Joined: Aug 02
Posts: 272

Re:Fired up the CS today--at long last! (long)

Deadstang, congrats on your progress! Firing the engine after it sits for a long time is a great feeling.

Cesar, great job on getting your car on the road. The interior is probably the cheapest job left, so long as you don't mind using those reproduction kits. For around $500 you can have an all-new interior -- you're in the home stretch!

We're in the home stretch on our house-buying process, too. We close this Friday! Thanks again to everyone who bid on/bought my GT/CS stuff (especially Ron) ;D We couldn't have done it without you guys!

-Winston
StraightSix is offline   Reply With Quote
Reply

  CaliforniaSpecial.com Forums > GT/CS and HCS Forums > GT/CS and HCS Discussions

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -7. The time now is 08:06 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2017, vBulletin Solutions Inc.


This site created, owned and maintained by Jon Hanna - Copyright 1996-2011
All rights reserved. CaliforniaSpecial.com is not affiliated with Ford Motor Company

ShowCase vBulletin Plugins by Drive Thru Online, Inc.